大體積混凝土測溫檢測報告

混凝土測溫檢測報告工程名稱/委托編號/委托單位/工程地點/建設單位/監理單位/施工單位/設計單位/檢測部位/檢測類別/檢測原因混凝土溫度監測檢測日期2023.07.02～2023.07.08檢測環境條件自然報告日期2023.07.09檢測依據《大體積混凝土施工標準》GB50496-2023檢測結論本工程根底承臺混凝土方量為77m3，測溫從2023年7月2日至2023年7月8日，總計6天?；炷翂K體溫峰值在澆筑后1～3天出現，最高溫度值為69.0℃〔測溫點1中部〕，平均入模溫度為35.9℃。各站點傳感器溫度值詳見附表1～附表3，各站點傳感器溫度曲線詳見附圖2～附圖4。從混凝土測溫值、溫度曲線及以上數據結合現場實體進行分析觀察可知：該根底承臺混凝土澆筑體在入模溫度根底上的升溫值為33.1℃，溫升值不大于50℃；混凝土澆筑塊體的里表溫差為9.8℃，不大于25℃；混凝土澆筑體的最大降溫速率為5.4℃/d，根據GB50496-2023的要求，混凝土澆筑體在入模溫度根底上的溫升值差、混凝土澆筑塊體的里表溫差符合要求；混凝土澆筑體的最大降溫速率、混凝土澆筑體外表與大氣溫不符合標準要求。建議施工單位應及時做好保溫養護措施。備注/聲明1、報告未蓋檢測單位“檢測報告專用章〞無效；2、復制報告未重新加蓋檢測單位“檢測報告專用章〞無效；3、對報告假設有異議，應于十五日內向檢測單位提出；4、有關檢測數據未經允許，委托單位不得擅自向社會發布報告信息。校核：試驗：混凝土測溫檢測報告〔附錄〕一、工程概況：受***委托對某工程的根底承臺砼進行溫度監測，該根底承臺混凝土厚度為1200mm。二、檢測依據：《大體積混凝土施工標準》GB50496-2023《某工程施工圖》三、檢測內容及檢測目的：檢測內容：根底承臺混凝土內的溫度場分布。檢測目的：實時監測混凝土在施工和養護期間，沿承臺深度和寬度方向的混凝土溫度變化狀態，實行信息化控制，及時調整保溫及養護措施，使混凝土溫度梯度和溫度增值不致過大，以有效控制有害裂縫的出現。檢測儀器設備：本次監測采用由濟********公司生產的ADS版數據采集器4臺〔編號：**********〕和傳感器。五、溫控指標及報警線：根據GB50496-2023的要求，本工程溫控指標為：混凝土澆筑體在入模溫度根底上的溫升值不宜大于50℃；混凝土澆筑塊體的里表溫差〔不含混凝土收縮的當量溫度〕不宜大于25℃；混凝土澆筑體的降溫速率不宜大于2.0℃；混凝土澆筑體外表與大氣溫差不宜大于20℃。六、測溫點布置本次監測在承臺平面共布置3個平面測溫點位，每個平面測溫點位沿厚度分別布置3個測溫點，詳見附圖1、附圖6。七、測溫記錄：本次測溫時間從2023年7月2日至2023年7月8日，總計6天，測溫間隔3小時，各站點傳感器溫度值詳見附表1～附表3，各站點傳感器溫度曲線詳見附圖2～附圖4，環境溫度測溫間隔3小時，環境溫度值詳見附表4，環境溫度溫度曲線詳見附圖5。附表1-1數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0219:31135.8℃36.3℃35.0℃1.3℃2023-07-0222:31136.9℃38.2℃38.4℃1.5℃2023-07-0301:32138.6℃40.7℃39.7℃2.1℃2023-07-0304:33139.3℃42.0℃42.9℃3.6℃2023-07-0307:34139.2℃44.8℃44.2℃5.6℃2023-07-0310:34140.5℃47.5℃46.3℃7.0℃2023-07-0313:35141.9℃48.2℃47.7℃6.3℃2023-07-0316:35142.2℃50.1℃50.7℃8.5℃2023-07-0319:36144.2℃52.8℃52.8℃8.6℃2023-07-0322:37147.1℃55.9℃53.6℃8.8℃2023-07-0401:38148.4℃56.3℃56.9℃8.5℃2023-07-0404:38150.7℃58.9℃58.8℃8.2℃2023-07-0407:39154.4℃61.7℃59.1℃7.3℃2023-07-0410:39158.0℃63.4℃61.8℃5.4℃2023-07-0413:40161.4℃65.8℃64.6℃4.4℃2023-07-0416:41163.7℃68.1℃65.4℃4.4℃2023-07-0419:42163.0℃69.0℃66.7℃6.0℃2023-07-0422:43161.5℃66.4℃64.5℃4.9℃2023-07-0501:43161.1℃66.2℃63.9℃5.1℃2023-07-0504:44160.2℃65.4℃63.2℃5.2℃2023-07-0507:45159.9℃64.8℃62.5℃4.9℃2023-07-0510:45159.0℃64.0℃62.0℃5.0℃2023-07-0513:46158.3℃63.6℃61.2℃5.3℃2023-07-0516:46157.5℃62.7℃60.8℃5.2℃2023-07-0519:47157.4℃62.1℃59.9℃4.7℃2023-07-0522:48156.6℃61.7℃59.4℃5.1℃2023-07-0601:48155.6℃60.9℃59.0℃5.3℃2023-07-0604:49154.9℃60.1℃58.5℃5.2℃2023-07-0607:50154.4℃59.8℃57.6℃5.4℃2023-07-0610:51153.9℃58.6℃57.2℃4.7℃2023-07-0613:51153.3℃58.1℃56.3℃4.8℃2023-07-0616:52152.8℃57.3℃55.4℃4.5℃2023-07-0619:53152.0℃57.0℃54.8℃5.0℃2023-07-0622:54151.5℃56.6℃54.4℃5.1℃2023-07-0701:55150.3℃55.8℃53.7℃5.5℃2023-07-0704:56150.2℃54.7℃53.1℃4.5℃2023-07-0707:57149.2℃54.4℃52.2℃5.2℃2023-07-0710:57148.5℃53.4℃51.5℃4.9℃2023-07-0713:58148.3℃53.0℃51.2℃4.7℃2023-07-0717:00147.7℃52.7℃50.3℃5.0℃附表1-2數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0720:00146.9℃51.5℃49.4℃4.6℃2023-07-0723:01145.8℃51.2℃49.3℃5.4℃2023-07-0802:03145.6℃50.5℃48.6℃4.9℃2023-07-0805:03145.1℃49.8℃48.1℃4.7℃2023-07-0808:04143.9℃48.8℃46.8℃4.9℃本頁以下空白附表2-1數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0219:31236.0℃37.0℃36.2℃1.0℃2023-07-0222:32238.4℃37.5℃38.3℃0.9℃2023-07-0301:32237.7℃39.3℃40.8℃3.1℃2023-07-0304:32239.7℃43.2℃41.1℃3.5℃2023-07-0307:33240.2℃44.5℃43.7℃4.3℃2023-07-0310:34241.0℃46.8℃46.8℃5.8℃2023-07-0313:34242.2℃48.3℃47.9℃6.1℃2023-07-0316:35243.7℃50.0℃50.2℃6.5℃2023-07-0319:35244.4℃52.0℃52.4℃8.0℃2023-07-0322:37246.4℃54.8℃54.4℃8.4℃2023-07-0401:37249.6℃56.7℃56.0℃7.1℃2023-07-0404:38250.4℃60.2℃58.0℃9.8℃2023-07-0407:39253.8℃61.7℃59.7℃7.9℃2023-07-0410:39257.6℃63.7℃62.5℃6.1℃2023-07-0413:40260.5℃64.4℃63.9℃3.9℃2023-07-0416:40262.7℃68.3℃65.5℃5.6℃2023-07-0419:41263.0℃67.9℃65.6℃4.9℃2023-07-0422:42261.8℃66.8℃65.0℃5.0℃2023-07-0501:43260.8℃66.1℃64.0℃5.3℃2023-07-0504:43260.7℃65.5℃63.5℃4.8℃2023-07-0507:44259.6℃64.5℃63.0℃4.9℃2023-07-0510:46259.2℃63.9℃62.2℃4.7℃2023-07-0513:46258.6℃63.7℃61.6℃5.1℃2023-07-0516:47257.8℃62.9℃60.7℃5.1℃2023-07-0519:47257.2℃61.8℃60.1℃4.6℃2023-07-0522:48256.8℃61.4℃59.3℃4.6℃2023-07-0601:49256.1℃60.6℃58.7℃4.5℃2023-07-0604:50255.3℃60.3℃58.4℃5.0℃2023-07-0607:50254.7℃59.5℃57.7℃4.8℃2023-07-0610:50253.8℃59.1℃56.7℃5.3℃2023-07-0613:52253.3℃58.2℃56.5℃4.9℃2023-07-0616:53252.7℃57.5℃55.5℃4.8℃2023-07-0619:53252.1℃56.9℃55.1℃4.8℃2023-07-0622:54251.3℃56.6℃54.1℃5.3℃2023-07-0701:55251.0℃55.4℃53.4℃4.4℃2023-07-0704:55250.1℃55.2℃52.9℃5.1℃2023-07-0707:57249.1℃54.6℃52.1℃5.5℃2023-07-0710:57248.4℃53.8℃51.7℃5.4℃2023-07-0713:58248.1℃53.2℃50.8℃5.1℃2023-07-0716:58247.5℃52.3℃50.6℃4.8℃附表2-2數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0719:58246.4℃51.8℃49.5℃5.4℃2023-07-0722:59246.4℃51.1℃49.1℃4.7℃2023-07-0802:00245.4℃50.3℃48.7℃4.9℃2023-07-0805:00245.0℃50.0℃47.5℃5.0℃2023-07-0808:02244.4℃48.9℃46.9℃4.5℃本頁以下空白附表3-1數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0219:32335.6℃36.4℃35.2℃1.2℃2023-07-0222:32337.5℃37.3℃38.8℃1.5℃2023-07-0301:33337.9℃40.8℃39.4℃2.9℃2023-07-0304:34338.4℃43.4℃42.0℃5.0℃2023-07-0307:36339.2℃45.4℃44.0℃6.2℃2023-07-0310:36341.7℃47.3℃45.4℃5.6℃2023-07-0313:37342.2℃48.0℃48.9℃6.7℃2023-07-0316:38342.7℃49.9℃49.1℃7.2℃2023-07-0319:38345.5℃53.4℃52.9℃7.9℃2023-07-0322:38346.8℃55.6℃54.9℃8.8℃2023-07-0401:38348.1℃57.2℃56.3℃9.1℃2023-07-0404:39350.2℃58.8℃57.3℃8.6℃2023-07-0407:40354.6℃61.6℃59.6℃7.0℃2023-07-0410:40357.3℃62.5℃61.1℃5.2℃2023-07-0413:41361.2℃65.4℃63.2℃4.2℃2023-07-0416:41363.5℃68.1℃66.6℃4.6℃2023-07-0419:42362.6℃67.7℃66.6℃5.1℃2023-07-0422:42361.5℃66.8℃64.4℃5.3℃2023-07-0501:43360.7℃65.9℃64.2℃5.2℃2023-07-0504:43360.1℃65.5℃63.2℃5.4℃2023-07-0507:43359.6℃65.0℃62.8℃5.4℃2023-07-0510:44359.0℃64.3℃61.8℃5.3℃2023-07-0513:45358.7℃63.2℃61.4℃4.5℃2023-07-0516:46357.7℃62.8℃60.9℃5.1℃2023-07-0519:47357.3℃62.4℃59.8℃5.1℃2023-07-0522:48356.6℃61.4℃59.5℃4.8℃2023-07-0601:48356.0℃60.7℃58.6℃4.7℃2023-07-0604:49355.0℃60.1℃58.4℃5.1℃2023-07-0607:50354.2℃59.6℃57.8℃5.4℃2023-07-0610:50353.9℃59.1℃57.2℃5.2℃2023-07-0613:50353.4℃58.1℃56.2℃4.7℃2023-07-0616:51352.5℃57.7℃55.8℃5.2℃2023-07-0619:52352.1℃56.8℃55.2℃4.7℃2023-07-0622:53351.5℃56.4℃54.3℃4.9℃2023-07-0701:54350.7℃55.9℃53.6℃5.2℃2023-07-0704:54349.7℃55.0℃52.7℃5.3℃2023-07-0707:55349.3℃54.0℃52.1℃4.7℃2023-07-0710:57348.5℃53.4℃52.0℃4.9℃2023-07-0713:57348.0℃53.3℃50.9℃5.3℃2023-07-0716:58347.3℃52.7℃50.5℃5.4℃附表3-2數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2023-07-0719:59347.0℃51.5℃49.7℃4.5℃2023-07-0722:59346.3℃51.1℃49.3℃4.8℃2023-07-0802:01345.7℃50.6℃48.6℃4.9℃2023-07-0805:02344.8℃50.1℃48.0℃5.3℃2023-07-0808:03344.1℃49.2℃47.2℃5.1℃本頁以下空白附表4-1溫度監測時間環境溫度溫度監測時間環境溫度溫度監測時間環境溫度2023-7-219:3230.8℃2023-7-57:5029.2℃2023-7-720:0333.2℃2023-7-222:3328.9℃2023-7-510:5132.8℃2023-7-723:0328.9℃2023-7-31:3427.3℃2023-7-513:5136.1℃2023-7-82:0427.9℃2023-7-34:3527.7℃2023-7-516:5234.9℃2023-7-85:0527.1℃2023-7-37:3629