BP1系列頻敏變阻器匯總

1、BP1系列頻敏變阻器匯總BP1系列頻敏變阻器匯總18/18BP1系列頻敏變阻器匯總BP1系列頻敏變阻器一、用途及型號意義本系列頻敏變阻器適用于容量自22千瓦至2240千瓦，50赫芝、三相交流線線型異步電動機的輕載及重載做有時起動用，比方：水泵、空壓機、軋鋼機、空氣壓縮機等。變阻器的型號及意義：BP1-/導線截面積（mm2）鐵芯編號（鋼管頻敏變阻器鐵芯編號（鋼管）設計序號鐵芯編號（鋼管）功率等級（千瓦）鐵芯編號分兩種：2號鐵芯：厚度12毫米鋼板，鐵芯輪廓尺寸為200290毫米。3號鐵芯：厚度12毫米鋼板，鐵芯輪廓尺寸為350440毫米。二、使用條件變阻器在以下條件下能可靠的進行工作：1、海拔不高

2、出4000米。12、周圍介質溫度不高于40及不低于-30。3、空氣相對濕度不大于85（205）。4、在無爆炸危院介質中，且介質中無足以腐化金屬和破壞絕緣的氣體及導電塵埃。5、有防雨雪及沒有充滿水蒸氣的地方。6、同意有一般震動和沖擊的地方。7、在與垂直面傾斜成任何角度的地方。三、結構及安裝尺寸變阻器是一種無觸點電磁元件，相當于一個等值阻抗。在電動機起動過程中，由于等值阻抗隨轉子電流頻率減小而自動下降（自動變阻），從而只須一級變阻器，就可以把電動機平穩地起動起來。變阻器實質上是一個鐵芯耗費特大的三相電抗器。它由數片山型鋼板疊合面的鐵芯及線圈兩個主要部份組成。鋼板間夾以墊圈，保持片間距離，以利散熱。

3、結構及安裝尺寸見圖一。BP1系列頻敏變阻器外形及安裝尺寸型號BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1BP1代號-204-205-206-208-210-212-305-306-308-310-312-316L1240240240240240240360360360360360360L2290290290290290290440440440440440440L3330330330330330330490490490490490490H1215215215215215215365365365365365365H2255255255255255255405405405405

4、405405B193108123153183213108123153183213273B2131146161191221251146161191221251311B3291306321351381441306321351381411471四、技術性能2輕載起動；傳動設備在起動過程中不帶負載或帶有略微負載。起動負載系數Pc0.10.5，起動力矩系數Pg0.7，轉子起動電流系數i2g1.251.6。一般起動時間小于20秒。比方：空氣壓縮機、水泵等。重輕載起動、分兩種情況。一種是傳動設備在起動過程中其阻力矩隨轉速的上升而下降，在起動時阻力矩較大。Pg0.50.8；起動力矩系數Pg1.0；轉子起動電流

5、系數12g1.62.0。起動時間大于20秒。比方：帶飛輪軋鋼機的電機傳動。另一種情況是傳動設備在起動過程中不帶負載或帶有略微負載，阻力矩較小，一般機體粗笨，且高速運轉，折算至電動機軸上的轉動慣量較大，起動時間經常高出20秒。本變阻同意連續起動數次，但總起動時間不得高出80秒。五、使用方法3接線方式；由于單臺變阻器體積重量不宜過大，故當電動機容量大到必然程度時就得多臺做串連使用，如圖二所示。抽頭，變阻器每相繞組上有五抽頭，一個抽頭設在繞組反面，編號為N，其余四個抽頭設在繞組正面，編號分別為1、2、3、4。抽頭1N間為100匝數，抽頭2N間，3N間，4N間分別為90，80，30匝數。（見圖三）調正

6、；如在使用過程中遇到以下情況可以調正面匝數平和隙。1、當起動電流過大，起動太快，可想法增加匝數，換接到1N抽頭，使用100匝數，匝數增加的奏效是起動電流的減少，起動力矩同時減少。2、當起動電流過小，起動力矩不夠，起動太慢時，可想法減小匝數，換接到3N抽頭（甚至采用14、24、34抽頭）使用80匝數（甚至更少），匝數減少的奏效是起動電流增大，起動轉矩同時增大。3、若是剛起動時嫌起動力矩大，機械有沖擊，但起動達成后牢固轉速以嫌低，起動達成短接時，沖擊電流較大，可在上下鐵芯間增設氣隙，增加氣隙的奏效是起動電流略微增加，起動力矩略微減小，但起動達成時力矩增大。牢固轉速得以提高六、系列表4BP1頻敏變阻

7、器系列表輕載重輕載輕載重輕載電機電機轉子每每電機電機轉子容量電流型號組型號組容量電流型號每組型號每組千瓦（安）臺臺千瓦（安）臺數臺數數數5163205/10051201-250308/63121316/40201226480205/80061230251-315308/50161316/32251-2881-100205/63081-280316-400380/40201316/25321101-125205/5010401-500308/32251316/2040151-63206/100051251-315310/50161310/63122并2964-80206/80061285316-

8、400310/40201310/50162-3581-100206/63081-355401-500310/32251310/40202101-125206/50101501-630310/25321310/3225251-63204/160031208/100051251-315312/50161312/63122并3664-80204/125041208/80061360316-400312/40201312/50162-4581-100204/100051208/63081-450401-500312/32251312/40202101-125204/80061208/50101501-

9、630312/25321312/3225264-80205/125011210/80061316-400316/40201316/50162并4681-100205/100051210/63081460401-500316/32251316/40202-55101-125205/80061210/50101-560501-630316/25321316/32252125-250205/63081210/40121631-800316/20401316/2532256-70126-160206/63081212/40121570316-400310/40202串310/50162串2161-20

10、0206/5010212/3216-710401-500316/3225310/4020并112201-250206/4012212/2502501-630310/5016310/32252112并251-315206/3216212/2025631-800310/4020310/2532212271-90161-200208/50101305/50161720-401-500312/22252串316/63123并201-250208/40121305/40121900501-630312/25322316/50163251-315208/32161305/32251631-800312/4

11、0202并316/40203316-400208/25201305/25321801-1000312/32252316/3225391161-200210/50101306/50161910-401-500316/32252串316/40202串2-115201-250210/40121306/402011.120501-630316/25322316/3225并251-315210/32161306/32251631-800316/40202并316/50164316-400210/25201306/25321801-1000316/32252316/4020454120201-550212

12、/40121308/402011.130631-800310/40202串2并316/63125并-140251-315212/32161308/32251-1400801-100316/32254316/50165316-400212/25201308/253211001-1250310/25324316/40205401-500212/20501308/204011251-1600310/20404316/32255145201-250305/63121310/402011.410801-1000316/50163并316/32252串3-180251-315305/5016310/322

13、51001-1250316/4020316/2532113并316-400305/4020310/25301.8001251-1600316/3225316/20406113401-500305/3225310/20401601-2000316/2530316/165061136185201-250306/63121312/402011.810801-1000316/32252串2并316/40202串4-225251-315306/5016312/3225-1001-1250316/2532316/3225并114316-400306/4020312/25302.2401251-160031

14、6/4020316/25328114并401-500306/3225312/20401601-2000316/3225316/2040811486BP2系列頻敏變阻器一、用途及結構特點BP2系列頻敏變阻器與BP1系列相同，用于輕載起動，電機容量101120千瓦。如空壓機、水泵等。結構與BP系列不一樣樣之處是鐵芯是用方鋼制成。依照電機容量不一樣樣鐵芯排數可為14排。型號及意義：BP2-/2導線截面積（mm）頻敏變阻器鐵芯編號（鋼管）設計序號鐵芯編號（鋼管）功率等級（千瓦）7二、性能及使用方法性能與BP1系列基實情像，使用與調整方法也可參照BP1系列。但線圈抽頭有四個：設在前面兩個，后邊兩個。抽頭

15、123（主）4抽頭123（主）4線圈號線圈號0318.524.501054.572.51854210321.527.56201062.582.5240424.531.57201372.595.5270527.536.58201482.5109.5310531.541.59501695.5125.50636.547.05019109.5144.536109410741.554.5125022125.5166.5470847.562.5144025144.5191.5試車時一般接抽頭1或抽頭3。調試中可合適調正到抽頭2或抽頭4上。三、系列表及采用方法選擇頻敏變阻器時步驟：（1）依照電機功率PH從表

16、3中查出換算系數（2）電機轉子電壓乘以E得UF值。（3）依照UF值從表4中直接查出頻敏變阻器的規格。8表3電動機功換算系數電動機功換算系數電動機功換算系數電動機功換算系數率PH千瓦E率PH千瓦E率PH千瓦E率PH千瓦E140.3171450.1663100.12657000.1012002711500.1643200.1252750.101280.2341550.1623300.1235800.100400.2461600.1603400.1226000.099450.2351650.1583500.1216250.098500.2261700.1573600.1206300.097550.2

17、171800.1543700.1186500.097600.2101850.1523800.1176800.095650.2041900.1513900.1167000.094700.1982000.1484000.1157100.094750.2102100.1454100.1147200.093800.2062150.1444250.1137500.092表3電動機功換算系數電動機功換算系數電動機功換算系數電動機功換算系數率PH千瓦E率PH千瓦E率PH千瓦E率PH千瓦E850.2012200.1434300.1127800.091900.1972500.1424400.1118000.09

18、0950.1932300.1414600.1108500.0881000.1902400.1384750.1089000.0861100.1832450.1374800.10810000.0831150.1812500.1365000.10610500.0811250.1752600.1345200.1051300.1722750.1325250.1041350.1702800.1315500.1031400.1683000.1285600.1029BP270系列起動用頻敏變阻器電動機功率PH千瓦UE頻敏型號22.825.9701/361325.929.7701/411329.734.2701

19、/471334.239.2701/540939.245.6701/6209103545.651.9701/702951.960.1701/820660.169.0701/950669.079.1701/1090679.191.1701/1250991.110.5701/1440426.129.30702/242629.3033.7702/272233.739.1702/312239.144.6702/361844.652.2702/4115357052.258.7702/471358.767.5702/541367.578.3702/621378.389.2702/720989.2103.47

20、02/8209103.4118.5702/95063034.3703/213034.338.6703/242638.644.3703/272244.351.5703/312251.558.6703/36187010558.667.1703/411567.177.2703/471377.288.6703/541388.6103703/6213103117.2703/7209117.2136703/820931.636.8704/183636.842.1704/213042.147.3704/242910514047.354.4704/272254.463.2704/272263.272.0704

21、/312272.082.5704/3618表四組數及接法星形星形星形星形星形1014021021028028042042056082.594.894.8109109126.423.426.726.730.030.034.534.540.140.145.745.752.352.360.160.169.069.080.280.291.391.3105.824.628.728.732.832.836.936.942.342.349.249.256.056.064.264.273.873.884.784.798.421.224.824.828.328.331.831.836.636.642.542.5

22、48.448.455.555.563.763.773.273.285.038.344.744.751.151.157.557.566.066.076.776.787.387.3100704/4713704/5413704/6213703/2130兩并星形703/2426703/2722703/3122703/3618703/4115703/4713703/5413703/6213703/7209703/8209704/1836兩并星形704/2130704/2429704/2722704/2722704/3122704/3618704/4713704/5413704/6213704/1836三

23、并星形704/2130704/2429704/2722704/2722704/3122704/3618704/4713704/5413704/6213704/18362并2串星形704/2130704/2429704/2722704/2722704/3122704/361811100115704/4713115132704/5413132153.4704/621333.238.7704/183638.744.2704/213044.249.8704/242949.857.1704/272257.166.3704/272256084066.375.5704/312275.586.6704/361

24、886.699.5704/471399.5114.2704/5413114.2132.7704/621329.934.9704/183634.939.9704/213039.944.8704/242944.851.5704/272251.559.8704/2722840112059.868.1704/312268.178.1704/361878.189.7704/471389.7103704/5413103119.7704/6213BP2系列頻敏變阻器外形及安裝尺寸型號BP2701BP2702BP2703代號L1240240240L2300300300L3330330330H121521521

25、5H2270270270B1102162222B2124184244B32843444043并2串星形4并2串星形BP270424030033021527028230446412BP3系列頻敏變阻器一、用途本系列頻敏變阻器適用于2.2125千瓦，JZR系列繞線型異步感覺電靈巧頻頻操作情況下的起動。頻敏變阻器常接于電機轉子回路中，一般不另裝短接裝置。二、頻敏變阻器工作條件依照操作的頻頻程度不一樣樣可分為三類第一類：稍頻頻，每小時100400次。機械車間的橋式吊車上除主鉤外，平移機構上的電機，出爐輥道拉鋼機等。大多數是剛起動就斷電。第二類：較頻頻，每小時400600次。冶金軋鋼車間橋式吊車，除主鉤

26、外，平移機構上的民機，軋機前后工作輥道，廷伸輥道等。大多數是起動剛就斷電。第三類：頻頻操作，每小時6001000次。起落臺、起落臺輥道，壓下裝置，撥鋼機，軋機中輥。三、系列表依照電機規格操作頻頻程度的不一樣樣可在系列表5中，直接查出頻敏變阻器的規13BP3頻敏變阻器系列表（適用于JZR系列電機）電機電機每小時起動100-400次每小時起動400-600次轉子電機型號功率每組每組電流型號型號千瓦臺數臺數安JZR11-612.82.21BP3-003/112031JZR12-612.23.5BP3-003/112031BP3-005/100031JZR21-620.65BP3-005/100401

27、BP3-008/80041JZR22-621.67.5BP3-008/100041BP3-012/80041JZR31-635.611BP3-506/63081BP3-510/50081JZR31-8287.5BP3-008/80061BP3-012/63061JZR41-846.711BP3-506/50101BP3-510/40101JZR42-846.316508/10041BP3-512/40101JZR51-870.522512/50101BP3-408/40161JZR52-874.330406/63161-410/40161JZR61-1013330406/32251-410/2

28、5251JZR62-1013845410/50161-408/50122JZR63-1018060412/25321-410/40162JZR71-1016780408/50161-412/40162JRR72-10170100410/50162-40840164JZR73-10175125412/50162-410/40164每小時起動600-1000次型號每組臺數BP3-005/80031BP3-008/80031BP3-012/63041BP3-510/63041BP3-406/63061BP3-510/50061BP3-406/50101408/50101412/32161408/63

29、082408/40122412/40122408/32164410/32164412/32164408/32168BP3頻敏變阻器系列表（適用于JXR2系列電機）電機電機每小時起動100-400次每小時起動400-600次每小時起動600-1000次轉子電機型號功率每組每組每組電流型號型號千瓦臺數臺數型號安臺數JZR2-11-611.82.21BP3-003/112031BP3-005/80031JZR2-12-612.13.5BP3-003/112031BP3-005/100031BP3-008/80031JZR2-21-617.75BP3-005/100401008/80041012/63

30、041JZR2-22-618.97.5-008/100041012/80041510/80041JZR2-31-632.211-506/63081510/63061406/80061JZR2-31-827.27.5-008/80061012/63061510/63061JZR2-41-849.211-506/50101510/40101406/50101JZR2-42-84916508/50101512/63101408/80101JZR2-51-864.122512/40121408/50121412/40121JZR2-52-86730406/63121410/50121408/80062

31、-61-10145.630406/32321410/25321408/3216262-1015840408/32321412/20321410/43216263-10164.850410/25321408/40162412/32162-64-1015465412/32321410/40162408/3216471-1017680408/5016241240162410/3216472-10177.2100410/50162408/40164412/3216473-10181125412/50162410/40164408/3216614BP3頻敏變阻器外形及安裝尺寸斷念編054號BP3BP3B

32、P3BP3BP3BP3BP3BP3BP3BP3BP3BP3排數代號-003-005-008-012-506-508-510-512-406-408-410-412L1150150150150220220220220320320320320L2195195195195290290290290440440440440L3230230230230355355355355510510510510H1181181181181215215215215365365365365H2221221221221260260260260410410410410B1821081471991581942302661632

33、09255301B2112138177229198234270306203249295341B327229833738935839443046636340945550615BP4系列頻敏變阻器一、用途及型號意義本系列頻敏變阻器適用于14000千瓦繞線型異步感覺電動機作重載有時起動作用。比方球磨機破碎機等。型號意義BP4-/2導線截面積（mm）頻敏變阻器鐵芯編號（鋼管）設計序號鐵芯編號（鋼管）功率等級（千瓦）二、起動性能負載力矩Pc=0.71.0起動力矩Pg=1.2起動電流與切除電流之比，小于2.5倍額定電流。同意連續起動三次，但總起動時間不得高出90秒。16三、系列表電機容量電機轉子型號每組電

34、機容量電機轉子電型號每組（千瓦）電流（安）臺數千瓦流（安）臺數1425253002501/24504116020020125020009/090321314002501/19605125131520009/071401415002501/14006131640020009/056501516302501/11208140150020009/045631648002501/090102540415004002/15506120125020125025010/090321516304002/12508125131525010/071401648004002/10010131640025010/0565018110004002/08012140150025010/04563110112504002/0631614050648005003/1121012513152513153151118110005003/09012131640008040110112505003/07116140150031511/06350112616005003/05620150163031511/05063216120005003/04525116008/06340506310112506304/10016131540025131540012/1004011261600630