GQZ球型支座設計參數表

1、GQ探列橋梁球型支座設計參數表設計承載力：100060000kN（執行標準GB/T17955-2009）名稱圖號說明12GQZ-SX求型支座組裝示意圖3GQZ-SX求型支座主要設計參數表（表-1）411GQZ-D湫型支座組裝示意圖12GQZ-D湫型支座主要設計參數表（表-2）1320GQZ-G咪型支座組裝示意圖21GQZ-G咪型支座主要設計參數表（表-3）2225、本GQZR列橋梁球型支座設計參數表系與國標橋梁球型支座GB/T17955-2009配套產品，本參數表供生產廠家發布GQZK列產品信息使用，以方便橋梁設計人員選型。二、GQ帝列支座的代號舉例:本例表示GQZ列橋梁球型支座承載力為100

2、00kN,縱向位移土100mm橫向位移土40mm轉角為0.03rad的雙向活動球形支座。三、GQZK列支座的主要技術性能1、支座豎向承載力分為30級，1000、1500、2000、2500、3000、3500、4000、4500、5000、6000、7000、8000、9000、10000、12500、15000、17500、20000、22500、25000、27500、30000、32500、35000、37500、40000、45000、50000、55000、60000kN。2、支座設計轉角。分為0.02、0.03、0.04、0.05、0.06rad五級。3、支座設計位移量:縱向位移：

3、10004500kN,E1=苴0、Ez=±100、E3=±150mm500017500kN,Ei=土00、巳=±150、E3=±200mm1中交公路規劃設計院有限公司名稱說明圖號12000037500kN,E=±150、巳=±200、E3=i250mm4000060000kN,Ei=i200、E2=±250、E=均00mm橫向位移：SX（雙向活動支座），10009000kN,e=i20mm1000060000kN,e=功0mmDX（單向活動支座）e=±3mm支座縱向、橫向位移量還可根據實際需要進行調整。4、支座可承

4、受的水平力：單向活動支座（D為及固定支座（GD在非滑移方向的水平力均不小于支座設計承載力的10%四、GQZK列支座安裝：1、采用本系列支座時，安裝支座的墊石混凝土強度等級不得低于C40級。2、安裝支座處應設置支座墊石，墊石尺寸應按局部承壓計算，其長度、寬度比支座底板尺寸大100m”上，高度不小于100mm且應布置鋼筋。并按支座底板地腳螺栓間距與底柱規格預留螺栓孔位置。若采用預埋鋼板焊接連接時，支座就位后，用對稱斷續方式焊接，焊接過程中應防止支座鋼體溫度過高，防止變形、燒壞聚四氟乙烯板等。3、支座安裝標高應符合設計要求?？刂茐|石頂面標高時要注意預留支座底板下專用砂漿墊層厚度。支座支承面四角高差不

5、得大于1mm4、支座安裝前方可開箱，并檢查支座各部件及配件清單。支座安裝前不允許隨意拆卸固定件。5、支座安裝的注意事項：1）支座安裝位置劃出中心十字，支座順橋方向的中心線應與主梁順橋向中心線平行。2）活動支座的上頂板與下底盆順橋方向的中心線應重合。3）支座安裝過程中，不得松開上頂板與下底盆的連接固定板，以防止發生過大的轉角而傾覆。待支座安裝完成后再拆除連接板，以防約束梁體的正常位移與轉動。4）檢查不銹鋼板外露面是否清潔，在運輸、儲存、安裝過程中涂裝是否碰掉，發現問題應及時清潔及補刷涂裝，然后安裝防塵設施。6、支座安裝還應滿足現行橋梁施工規范的相關規定。支座使用期間，應按養護規范的有關規定定期進

6、行檢查及養護。1中交公路規劃設計院有限公司名稱說明圖號2注：1,主要瑞翎：1-下底盆2_艇和豺赫家醐械觥平面聚酰乙敝平面不銹就上賊銅擋圈錨般栓2、其主要尺寸膈-1.1做公路規劃設計m限公司名稱GQZ-SX求型支座組裝示意圖圖號313f迎下載表-1（一）GQZ系列橋梁球型支座（S為雙向活動支座主要尺寸（mm）序號規格、'、縱向位移量A8=0.028=0.039=0.04伊0.05X0.06EE2乓EE2乓巳e2E3E1E2E§E3EE2E31GQZ-1000+50+100+150420520620440540640450550650一一一一一2GQZ-1500+50+100+1

7、50470570670480580680500600700一一一一一3GQZ-2000+50+100+150510610710540640740550650750一一一一一4GQZ-2500+50+100+150560660760580680780610710810一一一一一5GQZ-3000+50+100+150590690790620720820650750850一一一一一6GQZ-3500+50+100+150630730830660760860690790890一一一一一7GQZ-4000+50+100+150650750850680780880710810910一一一一一8GQZ-4

8、500+50+100+150690790890720820920750850950一一一一一9GQZ-5000+100+150+200810910101084094010408709701070一一一一一10GQZ-6000+100+150+20089099010909201020112096010601160一一一一一11GQZ-7000+100+150+2009301030113097010701170101011101210一一一一一12GQZ-8000+100+150+20096010601160101011101210106011601260一一一一一13GQZ-9000+100+1

9、50+200101011101210106011601260111012101310一一一一一14GQZ-10000+100+150+200105011501250109011901290114012401340一一一一一15GQZ-12500+100+150+200113012301339118012801380123013301430一一一一一續表-1（一）GQZ系列橋梁球型支座（SX雙向活動支座主要尺寸（mm）序號規格、'、縱向位移量A伊0.02伊0.03X0.049=0.058=0.06E1e2E3EE2E3EE2E3EE2巳E2E3E1E2E316GQZ-15000+100+

10、150+20012001300140012601360146013101410151013701470157014201520162017GQZ-17500+100+150+20012801380148013301430153013901490159014501550165015101610171018GQZ-20000+150+200+25014401540164015001600170015601660176016301730183016901790189019GQZ-22500+150+200+25015401640174016001700180016701770187017301830

11、193018001900200020GQZ-25000+150+200+25015501650175016501750185017201820192017901890199018601960206021GQZ-27500+150+200+25016501750185017101810191017801880198018501950205019302030213022GQZ-30000+150+200+25017101810191017701870197018401940204019202020212019902090219023GQZ-32500+150+200+250178018801980

12、18401940204019102010211019802080218020602160226024GQZ-35000+150+200+25018201920202018901990209019602060216020402140224021202220232025GQZ-37500+150+200+25018701970207019402040214020102110221020902190229021802280238026GQZ-40000+200+250+30020402140224021002200230021802280238022702370247023502450255027G

13、QZ-45000+200+250+30021202220232021802280238022602360246023502450255024402540264028GQZ-50000+200+250+30022102310241022802380248023602460256024502550265025402640274029GQZ-55000+200+250+30022802380248023502450255024402540264025302630273026202720282030GQZ-60000+200+250+3002360246025602430253026302520262

14、027202620272028202720282029201志迎下載表-1（二）GQZ系列橋梁球型支座（S為雙向活動支座主要尺寸（mm）序號規格橫向位移BA伊0.029=0.039=0.049=0.058=0.069=0.028=0.03X0.048=0.058=0.06E1E2E3EE2E3E1E2EiE2EiE21GQZ-1000+20360380390一一360460560380480580390490590-2GQZ-1500+20410420440一一4105106104205206204405406403GQZ-2000+20450480490一一45055065048058068

15、0490590690-4GQZ-2500+20500520550一一500600700520620720550650750-5GQZ-3000+20530560590一一5206207205506507505806807806GQZ-3500+20570600630一一5606607605906907906207208207GQZ-4000+20590620650一一580680780610710810640740840-8GQZ-4500+20630660690一一620720820650750850680780880-9GQZ-5000+20650680710一一7208209207508

16、50950780880980-10GQZ-6000+20730760800一一800900100083093010308709701070-11GQZ-7000+20770810850一一8409401040880980108092010201120-12GQZ-8000+20800850900一一86096010609101010111096010601160-13GQZ-9000+20850900950一一910101011109601060116010101110121014GQZ-10000+409309701020一一950105011509901090119010401140124

17、015GQZ-12500+40101010601110一一102011201220107011701270112012201320-續表-1（二）GQZ系列橋梁球型支座（SX雙向活動支座主要尺寸（mm）序號規格、'、橫向位移BA6=0.02伉0.03伉0.04伉0.05伉0.068=0.028=0.039=0.048=0.059=0.06E1e2E3EEie2E3eE2E3E1E2E316GQZ-15000+401080114011901250130010901190129011501250135012001300140012601360146013101410151017GQZ-17

18、500+401160121012701330139011601260136012101310141012701370147013301430153013901490159018GQZ-20000+401220128013401410147013201420152013801480158014401540164015101610171015701670177019GQZ-22500+401320138014501510158014201520162014801580168015501650175016101710181016801780188020GQZ-25000+40133014301500

19、1570164014201520162015201620172015901690179016601760186017301830193021GQZ-27500+401430149015601630171015201620172015801680178016501750185017201820192018001900200022GQZ-30000+401490155016201700177015801680178016401740184017101810191017901890199018601960206023GQZ-32500+40156016201690176018401640174018

20、4017001800190017701870197018401940204019202020212024GQZ-35000+401600167017401820190016801780188017501850195018201920202019002000210019802080218025GQZ-37500+401650172017901870196017301830193018001900200018701970207019502050215020402140224026GQZ-40000+40172017801860195020301890199020901950205021502030

21、2130223021202220232022002300240027GQZ-45000+401800186019402030212019702070217020302130223021102210231022002300240022902390249028GQZ-50000+401890196020402130222020502150225021202220232022002300240022902390249023802480258029GQZ-55000+40196020302120221023002120222023202190229023902280238024802370247025

22、7024602560266030GQZ-60000+4020402110220023002400219022902390226023602460235024502550245025502650255026502750表-1（三）GQZ系列橋梁球型支座（S為雙向活動支座主要尺寸（mm）序號目規格、BGDC、D8=0.028=0.038=0.048=0.058=0.06伊0.029=0.03伊0.04伊0.05X0.06伊0.029=0.038=0.048=0.058=0.061GQZ-1000300320330一一300320330一一240260270一一2GQZ-1500350360380一

23、一350360380一一290300320一一3GQZ-2000390420430一一390420430一一330360370一一4GQZ-2500440460490一一440460490一一380400430一一5GQZ-3000460490520一一470500530一一400430460一一6GQZ-3500500530560一一510540570一一440470500一一7GQZ-4000520550580一一530560590一一460490520一一8GQZ-4500560590620一一570600630一一500530560一一9GQZ-5000560590620一一59062

24、0650一一500530560一一10GQZ-6000640670710一一670700740一一580610650一一11GQZ-7000680720760一一710750790一一620660700一一12GQZ-8000700750800一一740790840一一640690740一一13GQZ-9000750800850一一790840890一一690740790一一14GQZ-10000830870920一一830870920一一730770820一一15GQZ-125009009501000一一9109601010一一800850900一一續表-1（三）GQZ系列橋梁球型支座（SX

25、雙向活動支座主要尺寸（mm）序號目規格B1GDC、D9=0.02伊0.03X0.04伊0.05X0.06伊0.029=0.038=0.04伊0.05X0.06伊0.029=0.03伊0.04X0.05伊0.0616GQZ-15000970103010801140119098010401090115012008709309801040109017GQZ-17500104010901150121012701060111011701230129094099010501110117018GQZ-200001100116012201290135011201180124013101370100010601

26、1201190125019GQZ-2250012001260133013901460122012801350141014801100116012301290136020GQZ-2500012001300137014401510123013301400147015401100120012701340141021GQZ-2750013001360143015001580133013901460153016101240126013301400148022GQZ-3000013601420149015701640139014501520160016701260132013901470154023GQZ

27、-3250014201480155016201700146015201590166017401320138014501520160024GQZ-3500014601530160016801760150015701640172018001360143015001580166025GQZ-3750015101580165017301820155016201690177018601410148015501630172026GQZ-4000015701630171018001880162016801760185019301470153016101700178027GQZ-450001650171017

28、9018801970170017601840193020201550161016901780187028GQZ-5000017301800188019702060179018601940203021201630170017801870196029GQZ-5500018001870196020502140186019302020211022001700177018601950204030GQZ-60000187019402030213022301940201021002200230017701840193020302130表-1（四）GQZ系列橋梁球型支座（S為雙向活動支座主要尺寸（mm）序號規

29、格'、H地腳螺栓底柱總重量（kg）W0.02e=0.039=0.049=0.05e=0.066=0.029=0.036=0.04伉0.056=0.06EE2巨日巨E3日E2E3日巨E3日巨E31GQZ-1000838485642>25255.661.867.962.569.075.466.673.279.92GQZ-1500868788642>25276.683.991.281.388.996.589.797.6105.43GQZ-2000919293642>25299.6108.0116.5114.1123.1132.0119.5128.7137.94GQZ-250

30、0969799642>252131.4141.1150.8142.8152.8162.9161.7172.4183.15GQZ-3000100102103646>260155.8166.6177.4175.7187.2198.6197.2209.1221.36GQZ-3500105106108646>260190.9202.9215.0212.1224.7237.4236.2249.5262.87GQZ-4000109111113646>260214.0226.8239.7238.7252.3266.0264.8279.1293.48GQZ-45001131151176

31、46>260254.6269.0283.4282.2397.1312.2311.3327.0342.69GQZ-5000117119121658>300298.2313.5328.5328.1344.1360.1359.8376.5393.110GQZ-6000125127130658>300405.2423.4441.7442.9462.0481.0494.0514.0534.011GQZ-7000132134137658>300480.3500.7521.2535.3556.9578.3592.8615.4638.012GQZ-8000139141143670>

32、;352549.0572.2595.4623.5648.1672.7701.6727.6753.613GQZ-9000145147149670>352651.2677.1703.0734.7762.1789.5821.3850.3879.314GQZ-10000152154156670>352767.4797.2827.0839.3870.5901.4933.8966.5999.215GQZ-12500173175177680>3521038.41074.01109.61148.61186.01223.41270.81309.91349.0續表-1（四）GQZ系列橋梁球型支座

33、（S為雙向活動支座主要尺寸（mm）序H地腳螺栓底柱總重量（kg）號9=0.029=0.039=0.046=0.059=0.066=0.026=0.036=0.049=0.059=0.06EE2E3EE2E3日E2E3日E2E3E巨E316GQZ-15000188192196200(201)204(205)680X3521303.81343.71383.51457.91499.91541.81588.81632.51676.31803.81831.91891.41946.61994.42056.817GQZ-17500199201205(206)209(210)214(215)69QX400_1

34、581.71626.21670.81726.51772.91819.41903.21952.01951.32128.12179.22245.52347.02415.92470.418GQZ-20000214216221224229690Y4001942.41993.12043.82145.52198.52251.82384.82440.52496.22643.82702.32760.82895.62956.73017.719GQZ-22500221223227232238690X400_2371.02427.92484.82593.52652.92712.32880.02942.43004.7

35、3149.43214.53279.13480.43548.53616.620GQZ-250002322362412472506100V4002553.42612.82672.22920.43014.23078.13270.03336.93403.83619.03689.13759.13947.24020.24093.421GQZ-27500243245251254261100Y4003084.23150.33216.53339.13407.93476.83702.03774.23846.34043.14118.64193.94493.14572.14650.622GQZ-30000255258

36、2622682733516.73587.93659.13809.03882.13956.24175.24252.64329.94633.94715.24796.55049.95134.55219.223GQZ-325002672702742812863936.54011.34086.14241.54328.64416.24648.64730.04811.35122.15207.55293.05604.15693.15782.124GQZ-350002772792862912964369.74451.74533.64729.14814.24899.35199.35288.35377.15688.

37、05780.55873.16238.16334.86431.525GQZ-375002862892933023074897.84988.35078.95315.05409.45503.85774.05872.35970.66350.86453.46556.07038.37145.97253.526GQZ-400002973003043103155629.55727.95826.36022.46124.36226.16488.76595.16701.57272.17383.67495.27899.88016.08132.127GQZ-45000323324329334344120只4806709

38、.86819.86929.77125.37239.17352.77781.67900.28018.98535.78659.98784.09417.79547.39677.028GQZ-50000342344346354363120人4807833.07953.08073.08385.98510.48635.09057.39186.99316.49951.610086.810223.110905.011046.011187.129GQZ-55000361363366373381124入5208846.98976.09105.19509.39643.19776.810354.010493.6106

39、33.311809.811955.412101.112334.612486.212637.730GQZ-60000379381385393400124入520110132.610273.410414.110806.210951.811097.311759.111910.912067.312931.913090.713247.414130.314295.914461.5I2OK56U時"玨亳學蚪郵谿k-以學眄性赫2蜿餐-6-8.點-L繃,-9說防撕魁Y'盟戲日料巍m-p醐艇W3普省甌駐1翌氧T:混卻齡VI：雖Q1做公路規劃設計m限公司名稱GQZ-DX型支座組裝示意圖圖號12表-2（一）GQZ系列橋梁球型支座（DX單向活動支座主要尺寸（mm）序號規格、'、縱向位移量A伊0.02伊0.038=0.048=0.059=0.06E1E2E3EE2E3§E2E3E1E2E3EiE2E3EiE2E31GQZ-1000+50+100+150420520620440540640450550650一一一一一一2GQZ-1500+50+100+150470570670480580680500600700一一一一一一3GQZ-2000+50+100+150