底板和主線電氣ec-whbs13ub

1、UB090 CELL POWER DISTRIBUTION PANEL 400 AMPEC-WHBS-13-UB090&120-P1STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2013-9-10DRAWING PACKAGE REVISION LEVEL: ALAST PART SELECTED WITH :SGM WUHANREFERENCE USED:ENG. MGR:SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLP

2、ROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ASHEETNUMBER:1OF3GMSHEETTITLE AND REFERENCE SHEETDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROP

3、ERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SY

4、STEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ASHEETNUMBER:2OF3GMSHEETTABLE OF CONTENTSDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPO

5、SE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.SECTIONREVSHEETDESCRIPTIONSTATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-2SECTIONREVSHEETDESCRIPTIONAREFERENCE1TITLE AND REFERENCE SHEET2TABLE OF CONTENTS3MASTER CHANGE SHEETEMAGNETICS1380 VAC POWER DISTRIBUTION2380 VAC PO

6、WER DISTRIBUTION3380 VAC POWER DISTRIBUTION4220 VAC POWER BELOW DISCONNECT5220 VAC POWER BELOW DISCONNECT6220 VAC POWER BELOW DISCONNECTXENCLOSURE1ENCLOSURE LAYOUT2DOOR TAG DETAIL3ENCLOSURE SIDE LAYOUTS4ENCLOSURE SIDE LAYOUT DETAILS5ENCLOSURE LEFT & BOTTOM INSIDE AND TOP LAYOUT6SUBPLATE LAYOUT7TERMI

7、NAL ROTATION8RECEPTACLE PIN CHARTYABILL OFMATERIALS1BOM LISTYBBILL OFMATERIALS1DEVICE LIST2DEVICE LISTREVSHEETAFFECTEDCHANGE DESCRIPTIONDATECHANGECODECHANGEDBYSTATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2013-7-17REVSHEETAFFECTEDCHANGE DESCRIPTIONDATECHANGECODECHANGEDBYCHANGE CODE

8、SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ASHEETNUMBER:3OF3GMSHEETMASTER CHANGE SHEETDESCRIPTION

9、:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.PRPRODUCT CHANGERPLANT REQUESTMPMECHANICAL PROCESSCHANGECPCONTROL PROCESSCHANGEMMECHANICAL

10、 DESIGNCHANGECCONTROL DESIGNCHANGEFFLOOR AND BUILDCHANGE184166124114130162118116150170188120112156160132106178128186176154134152172110126138136168182180108164174158122WANGZPLOFSGM-CCRE16GMDESIGN SOURCE:YU FANGSGM-WH K211DESIGN LEADER: PROGRAMS:JIA NANGM ENGINEER:THIS MATERIAL IS THE PROPERTY OF GENE

11、RAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:380 VAC POWER DISTRIBUTIONSHEET DESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11

12、REVISIONLETTER:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1DATE:SECTION SHEETLETTER: NUMBER:380VAC POWER BELOW DISCONNECTPOWER DISTRIBUTION BLOCKSPE BARPOWER DISTRIBUTIONBLOCKSPE BAR114L1114L2外部進線PE直接連接到PE-BARPE1L1 1L2 1L3BK6 mm24135E106DISC6 400 AMP50 mm50 mmLBGNYEN150 mm BKBK6 mmBK6 mmBK6 mmPEPEUB090 R2

13、UB090 R1PEUB090 L3164L3164L2164L13456E164CB1230 AMP158L3158L2158L13456E158CB1230 AMPE152CB12345630 AMP152L3152L2152L1E114CB12345630 AMP114L3NPEBELOW DISCONNECTBK6 mmPEUB090 L1122L3122L2122L1E122CB12345630 AMPBK6 mmPEUB090 L2130L3130L2130L1E130CB12345630 AMPBK6 mmPEUB090 R3170L3170L2170L13456E170CB12

14、30 AMPBK6 mmPEUB100 L1176L3176L2176L1E176CB12345630 AMPBK6 mmPEUB100 R1182L3182L2182L1E182CB12345630 AMPE1391L11L2 1L3NPEE200E150100L1L2L3102104NSTATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2013-7-18PEL1L2 UB090&120 C1L3 MCP PANELNPE284266224214230262218216250270288220212256260232

15、206202278228200286276254234252272210226238204236268282280208264274258222WANGZPLOFSGM-CCRE26GMDESIGN SOURCE:YU FANGSGM-WH K211DESIGN LEADER: PROGRAMS:JIA NANGM ENGINEER:THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN T

16、HE FURNISHING OF SERVICES AND SUPPLIES.PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:380 VAC POWER DISTRIBUTIONSHEET DESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1DRAWING NUMBER:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISION LETTER:DATE:SECTION SHEETLETTER: NUMBER:POWER DI

17、STRIBUTION BLOCKSPE BARPOWER DISTRIBUTION BLOCKSPE BAR202L1202L2202L3E202CB12345630 AMPE208CB12345630 AMP208L1208L2208L3UB100 R2PEUB100 APCPEBK6 mm6 mm BKE214CB12345630 AMP214L1214L2214L3E220CB12345630 AMP220L1220L2220L3SPARESPAREPEPEBK6 mmBK6 mmE226CB12345620 AMP226L1226L2226L33456E232CB1250 AMP232

18、L1232L2232L3SPAREUB090 M1 VFDPEPEBK4 mm10 mm BK10 mm BKPEUB110 M1 VFD252L3252L2252L1E252CB12345650 AMPNNNE250E1891L1 1L2 1L3NPEE2391L1 1L2 1L3NPEE300STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-28338WANGZPLOFSGM-CCRE36GMDESIGN SOURCE:YU FANGSGM-WH K211DESIGN LEADER: PROGRAM

19、S:JIA NANGM ENGINEER:THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:380 VAC POWER DISTRIBUTIONSHEET DESCRIPTION:SY

20、STEM/TOOL NO:EC-WHBS-13-UB090&120-P1DRAWING NUMBER:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISION LETTER:DATE:SECTION SHEETLETTER: NUMBER:DISTRIBUTION BLOCKS300302304306308310312314316318320322324326328330332334336POWERPEBARE2891L11L2 1L3NPEE400STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&1

21、20-P1SAVE DATE: 2013-10-24E3391L11L2 1L3NPE400450402452E404CB4041L1124041E404LTN454x1x21.5 mm2 AMP1.5 mmAC POWER ON1.5 mm RDRDWH4064564081L11L1 E5504582.5 mmRD410NN E5504602.5 mmWH412462E414CB4141L112414L146410 mmRDUB090R PUMP1416N34414046610 mm50 AMPBKPE418468E420CB4201L112420L147010 mmRDUB090L&100

22、 PUMP1422N34420047210 mm50 AMPBKPE424474426476428478430480432482434484436486POWERPE438DISTRIBUTIONBAR488BLOCKSSGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1

23、RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ESHEETNUMBER:4OF6GMSHEET220 VAC POWER BELOW DISCONNECTDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNI

24、SHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-6-18E408E410500550E552LSPANEL LIGHTN1L1E552CBDOOR SWITCHE552LT1255212221x2x1N5025522 AMP1.5 mm1.5 mmBNBU1L15045542.5 mmPENRD2.5 mmWH506556E557CB1255715571UB090 D1NN5085584 AMP1.5 mmHMI AC1.5 mmRDPOWER

25、PEWH1.5 mm510560E560CBGNYE1256015601UB090 D2NPEN5125624 AMP1.5 mmHMI AC1.5 mmRDPOWERPEWH1L11.5 mmN514564E564CB GNYE1256415641UB090 D3NPEN5165664 AMP1.5 mmHMI AC1.5 mm1L1RDPOWERPEWHN2.5 mm1.5 mm2.5 mm518568RDE568CB GNYEWHPE1256815681SPARENN5205704 AMP1.5 mm1.5 mmRDPEWH1.5 mmN5225721L1E572CB GNYE12572

26、15721NPENSPARE5245744 AMP1.5 mm1.5 mmRDPEWH1.5 mm526576GNYEPE5285785305805325825345841L1N2.5 mm2.5 mm536586RDWH538588E600E600SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-

27、13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ESHEETNUMBER:5OF6GMSHEET220 VAC POWER BELOW DISCONNECTDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER

28、 THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-6-18600E588E588650602E603CBN652126031N4 AMP1.5 mmAC1-2UB090AC1-31.5 mm6041L1BKSOLA POWER 1N6542.5 mmAC1-11.5 mm2.5 mm606RDE607CB GNWH656PE126071N6084 AMP1.5 mmAC2-2UB090AC2-31.5 mm658BK

29、SOLA POWER 21L1AC2-11.5 mmN610 GN660E612CBPE612126121N6624 AMP1.5 mmAC3-2UB100AC3-31.5 mm1L1BKSOLA POWERN6142.5 mmAC3-11.5 mm2.5 mm664RD GNWHE616CBPE616126161N6664 AMP1.5 mmAC4-2UB120AC4-31.5 mm6181L1BKSOLA POWER1.5 mmN668AC4-1E620CB GN620126201PEN6704 AMP1.5 mmAC5-2SPAREAC5-31.5 mm1L1BKN6222.5 mmAC

30、5-11.5 mm2.5 mm672RD GNWHE624CBPE624126241N6744 AMP1.5 mmAC6-2SPAREAC6-31.5 mmBK626AC6-11.5 mm676 GNPE628678630680632682634684636686638688SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOO

31、L NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:ESHEETNUMBER:6OF6GMSHEET220 VAC POWER BELOW DISCONNECTDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY

32、PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-23400 mm電源分配柜POWER DISTRIBUTION PANEL電源：SUPPLY: 380 VOLTS, 3 PHASE, 50 HZ最大負載電流：FULL LOAD CURRENT: 400 AMP最大短路電流：SHORT CIRCUIT RATING: 65,000 AMPEC 號EC NUMBER: EC-WHBS-13

33、-UB090&120-P1生產日期：DATE OF MANUFACTURE: 2014-01警告 WARNING本柜體內有380-400V電壓打開本柜體前必須先斷開主隔離開關380-400 VOLTS IN PANELUSE DISCONNECT TO REMOVE POWERBEFORE SERVICING PANEL 22.5mm HOLEDOOR BONDING INSTRUCTIONS- SUPPLY GROUNDING STUD ON INTERIOR OF DOOR AND INSIDE-EPNRCOLOVISDUER1E6.mm COPPERBRAID BONDING CONDU

34、CTOR BETWEEN THE DOORS AND ENCLOSUREGROUNDING STUDS. USE50mm X 50mm CONTINUOUSNON-INSULATED CRIMPANGLE IRON WITH 16mm HOLES-RPINRGOLVUIDGEO1N6mEmACGHNBYREAIDFOR LAGGING ENCLOSURE TONOTE:EWNIRDE. BETWEEN THEFLOOR (2 PLACES)1 PROVIDE WIRE MANAGEMENT BARS ONENCLOSURE STUD ANDINSIDE LEFT OF ENCLOSURETHE

35、 GROUND BAR.2 PROVIDE A TAG WITH RECEPTACLE NAMEAND NUMBER OF PINS ON THE INSIDE ANDENCLOSURE3 OUTSIDE OF THE PANEL FOR EACH RECEPTACLEUSE DRIVE SCREWS OR THREADED SCREWS TO1400 H x 1200 W x 500 DFASTEN LEGEND TAGS IN PLACEBASE4 ENCLOSURE TO BE CONSTRUCTED TO CURRENT100 H x 1200 W x 500 D5 GCCB-1 AN

36、D GCCH-1 STANDARDSMOUNT DRAWING SHEETS E1 THROUGHE5 TO THE INSIDE OF THE DOORSGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLET

37、TER:DATE:SECTIONLETTER:XSHEETNUMBER:1OF8GMSHEETENCLOSURE LAYOUTDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASED

38、PROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-28警告WARNING本柜體內有380-400V電壓！TAG SIZE:電源分配柜打開本柜體前必須先斷開WHITE TEXT ON158mm W X 168mm HPOWER DISTRIBUTION PANEL380-400 主隔離開關 PANELRED BACKGROUNDUSE VOLTS INTAG SIZE:電源：DISCONNECTTO REMOVE POWER125mm W X 125mm HSUPPLY: 380 VOLTS, 3 PHASE, 50 HZBEFORE

39、SERVICING PANEL最大負載電流：FULL LOAD CURRENT: 400 AMP最大短路電流：SHORT CIRCUIT RATING: 65,000 AMPEC 號EC NUMBER: EC-WHBS-13-UB090&120-P1生產日期：DATE OF MANUFACTURE: 2014-01NOTES:交流電源1. ALL TAGS TO BE WHITE WITH BLACKACLETTERING UNLESS NOTED OTHERWISE.POWER ONTAG SIZE:E404LT50mm W X 60mm H4041N2. WIRE NUMBERS SHOW

40、N ON TAG FOR WIRINGPURPOSES ONLY. DO NOT MARK WIREGNNUMBERS ON TAGS.SGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:

41、SECTIONLETTER:XSHEETNUMBER:2OF8GMSHEETDOOR TAG DETAILDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NA

42、ME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-2175 mm75 mm 25 mm HOLE(12) PLACES 32 mm HOLE(6) PLACES 22 mm HOLE(12) PLACES75 mm 75 mm 100 mmLEFT SIDE VIEWRIGHT SIDE VIEWSGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANE

43、L 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:3OF8GMSHEETENCLOSURE SIDE LAYOUTSDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE

44、 SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-4-26E158CBE182CBE202CB UB090 R1UB100 R1UB100 R2E164CBE170CBE176CB UB090 R2UB090 R3UB100 L1E114CBE122CBE130CBUB090&120 MCPUB090 L1UB090 L2E152CBE208CB

45、E232CBUB090 L3UB100 APCUB090 M1 VFDE420CBE414CBE252CBUB090R&100 PUMP1UB090L PUMP1UB110 M1 VFDC/PC/PC/PAC3AC2AC1 3 PIN3 PIN3 PINAC6AC5AC4注意：3 PIN3 PIN3 PINC/PC/P1、側裝孔座的1芯應當依照柜體方向E564CB安裝在上方。UB090 D3 HMIAC POWER2、在柜體內外兩側孔座處加標牌，C/PC/P標明孔座名稱及插針芯數。BONDINGE560CBE557CB3、未使用的開孔應用孔塞遮蓋。UB090 D2 HMIUB090 D1 HM

46、IWIREAC POWERAC POWERNOTES:PIN #1 SHALL BE ORIENTED TO THE TOP OF THE ENCLOSURE FOR SIDE MOUNTED RECEPTACLES.PROVIDE A TAG WITH RECEPTACLE NAME AND NUMBER OF PINS ON THE INSIDE AND OUTSIDE OF THE PANEL FOR EACH RECEPTACLE.COVER PLATES REQUIRED ON ALL UNUSED RECEPTACLE OPENINGS.LEFT SIDE VIEWSGM-CCRG

47、M ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:4OF8GMSHEETENCLOSURE SIDE LAYOUT DETAILSDESCRIPTI

48、ON:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-28200 mm270mm220

49、mmC/P 25mm HOLE WITH HOLE PLUGFOR MAIN FEEDTOP VIEW420 mmTS-PE - (34) TERMINALS - GROUNDWARNING SHOCK HAZARD IFGROUND WIRE LOOSE200 mm200 mm100 mmINSIDE BOTTOM OF ENCLOSURE6mm HIGH BLACK TEXTON YELLOWWARNINGRIGHT INSIDE VIEWBACKTGARGOSUIZNED:SHOCK HAZARD IF100mm W X 38mm HGROUND WIRE LOOSESGM-CCRGM

50、ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:5OF8GMSHEETENCLOSURE LEFT & BOTTOM INSIDE AND TOP L

51、AYOUTDESCRIPTION:DRAWING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-4-30S

52、GM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:6OF8GMSHEETSUBPLATE LAYOUTDESCRIPTION:DRAW

53、ING NUMBER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.311 mm75 mm X 100 mm DUCT50 mm X 100 mm DUCT75 mm X 100 mm DUCT75 mm X 100 mm DUCT77 mm467 mm31

54、0 mm310 mm75 mm X 100 mm DUCT75 mm X 100 mm DUCTSUBPLATE 1300 H x 1100 W634 mm50 mm X 100 mm DUCT50 mm X 100 mm DUCT50 mm X 100 mm DUCT50 mm X 100 mm DUCT283 mmTS1 TERMINALS ACE106DISCN1L11L21L3E114CBE122CBE130CBE152CBE158CBE164CBE170CBE176CBE182CBE202CBE208CBE214CBE220CBE226CBE232CBE252CBE404CBE414

55、CBE420CBE552CBE560CBE564CBE568CBE572CBE603CBE607CBE612CBE616CBE620CBE624CBSTATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-21L11L11L11L11L156015681N N N N NSTATUS: RELEASEDPROJECT NAME: EC-WHBS-13-UB090&120-P1SAVE DATE: 2014-5-2TS11L11L11L11L11L1557156415721N N N N NSGM-CCRGM E

56、NGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:7OF8GMSHEETTERMINAL ROTATIONDESCRIPTION:DRAWING NUMB

57、ER:EC-WHBS-13-UB090&120-P1THIS MATERIAL IS THE PROPERTY OF GENERAL MOTORS CORPORATION. NO RIGHTS ARE GRANTED TO USE SUCH MATERIAL FOR ANY PURPOSE OTHER THAN THE FURNISHING OF SERVICES AND SUPPLIES.STANDWAI RD).COLORABBREVBLACKBKBROWNBNREDRDORANGEOGYELLOWYEGREENGNBLUEBUVIOLETVTGRAYGYWHITEWHPINKPKGOLD

58、GDTURQUOISETQSILVERSRGREEN WITHYELLOW TRACERGNYEBLACK WITHORANGE TRACERBKOGBLUE WITHORANGE TRACERBUOGWHITE WITHRED TRACERWHRDWHITE WITHORANGE TRACERWHOGNOTE:ALL UNUSED RECEPTACLE WIRES SHOULD HAVE ENDS PROTECTED WITH TAPE TO PREVENT UNINTENTIONALASLHLOWRTIRINEGS.ARE TO BE BLUE (BU) UNLESS OTHERWISE

59、SPECIFIED(MINI AND MICRO RECEPTACLE WIRE COLORS TO BE IN COMPLIANCE WITH THE ASSOCIATED IEC OR ANSITHE RECEPTACLE WIRES SHALL HAVE THE RECEPTACLE NUMBER AND PINMINI CONNECTORNUMBER LABELED ON BOTH ENDS.FEMALE - FACE VIEWEXAMPLEPINFUNCTION COLOR22081 (label)G1 - 28 (labels)RECEPTACLE1GROUNDGREENG1POW

60、ERBLACK22081323NEUTRALWHITE12.5 mm25 mmSGM-CCRGM ENGINEER:WANG JIA NANDESIGN SOURCE:YU FANGDESIGN LEADER:ZPLPROGRAMS: SGM-WH K211PACKAGEUB090 CELL POWER DISTRIBUTION PANEL 400 AMPDESCRIPTION:SYSTEM/TOOL NO:EC-WHBS-13-UB090&120-P1RELEASE DATE:2013-7-11REVISIONLETTER:DATE:SECTIONLETTER:XSHEETNUMBER:8O