液體混凝土無機鋁鹽防水劑

1、液體混凝土無機鋁鹽防水劑 液體混凝土無機鋁鹽防水劑施工作業指導書版權所有：北京海巖興業混凝土外加劑有限公司液體混凝土無機鋁鹽防水劑的技術性能及應用Inorganic Alumi num Salt Waterproof Agent一、用途：液體混凝土無機鋁鹽防水劑是以無機鋁鹽為主體的多種無機鹽類復 合制成的熔液。把它滲入混凝土、水泥砂漿中，即可配制成具有防滲、防 漏、防潮功能的防水砂漿，抹在建筑結構表面形成剛性永久防水層。二、使用范圍：運用于屋面、衛生間、地下室、水池、水塔、倉庫、橋梁、隧道、水渠、堤壩、人防工程的表層防滲防漏防潮。三、防水機理：混凝土、水泥砂漿在硬化過程中，由于水分蒸發留下許多

2、毛細通道和也隙，水的滲透就是通過這些毛細通道和孔隙進行的，無機鋁防水劑摻 入水泥砂漿后，即與水泥中的水化生成物發生化字反應，生成氫氧化鋁和 氫氧化鐵等不溶于水的膠體物質，同時還能與水泥中的水化鋁酸鈣作用， 生成具有一定膨脹性的復鹽硫鋁酸鈣晶體。這些膠體和晶體物質堵塞和填充了水泥砂漿在硬化過程中形成的毛細通道和孔隙，從而提高了水泥砂漿防水層的密實性，達到防水抗?jié)B的目的。四、技術指標：1、外觀：褐黃色透明液體，有微量雜質及沉淀物。2、 液體混凝土無機鋁鹽防水劑摻量占水泥重量5-15%時的水泥砂漿性能 指標：項目Item指標項目Item指標In dexIn dex體積安定性Con siste ncy

3、 involume合格Pass test抗拉強度Ten sile stre ngth提高率30%In creased 30%凝結時間Sett ing time初凝50 分鐘In itialsett ing 50mi n終凝W 4小時Fi nalsett ing 150%耐咼溫Thermal stability (up to)+110 c+110 c抗壓強度Compressive stre ngth提高率20%In creased耐寒冷Cryoge nic tolera nee-4 0C-4 0C 20%3、耐候性能試驗:試板在氙燈氣候試驗機中進行 300小時試驗，未出現裂紋、疏松、脫落、離層等

4、老化現象，防水面層完好，與原始試板無差異。五、包裝、貯存、保質期：液體混凝土無機鋁鹽防水劑用塑料桶封蓋包裝。每桶凈重50您士 1 kgo產品應貯存在溫度低于40 C的通風干燥倉庫內，桶口向上，不得靠近 火源和熱源，以防塑料桶老化變形。產品保質期為五年。在五年內無明顯 變色和干縮現象。六、配料要求：1、水泥：使硅酸鹽水泥、普通硅酸鹽水泥或礦渣硅酸鹽水泥，標號不低于32.5MPa。不同品種不同標號的水泥不能混合使用。2、砂：采用中砂、質量符合水泥砂漿用砂要求。3、水：用潔凈的淡水（飲用水）七、施工工藝：1、清理基層：把基層表面的油污、灰塵、雜物等清潔干凈。對光滑的基層表面還需進行鑿毛處理，麻面率不

5、得小于 75% ,。然后用水濕潤基層。2、刷結合層：在已鑿毛和干凈濕潤的基層上，用刷子均勻刷一道稀粘狀的水泥防水劑素漿（配合比為水泥：水：液體混凝土無機鋁鹽防水劑=1 : 2.20:0.10 ）作結合層。以提高防水砂漿與基層的粘合力。厚度以2伽左右為 宜。3、抹第一層防水砂漿（找平層）：在結合層未干之前必須及時抹第一層防水砂漿（配合比為水泥：中砂：水：液體混凝土無機鋁鹽防水劑 =1 : 2.5: 0.35: 0.15 ）作找平層，厚度以10伽左右為宜。搟光壓實后，用木抹搓出麻面。4、抹第二層防水砂漿：在找平層初凝后，應及時抹第二層防水砂漿，其配合比和厚度均與第一層防水砂漿相同，用鐵抹子反復壓平

6、壓光。5、潮濕養護：在第二層防水砂漿終凝之后，應及時養護，每天均勻澆水不得少于 五次，在保持潮濕條件下養護七天。液體混凝土無機鋁鹽防水劑由北京海巖興業混凝土外加劑有限公司獨家根據用戶需求研發生產，達到最基本的國家檢測標準，目前液體混凝 土無機鋁鹽防水劑錯綜復雜，價位層次不齊，都會做液體混凝土無機鋁鹽 防水劑，真正滿足客戶需求的有幾個，原應很簡單，是我們的使用客戶放 縱了生產者，貪便宜所造成的后果是給建筑物帶來安全隱患，我們的使用 者沒有受益。液體混凝土無機鋁鹽防水劑屬于北京海巖興業混凝土外加劑有限公 司獨家開發，發明人：于泳，在全國固定銷售人員，無任何授權代理公司， 工廠合同制生產，實地考察后

7、，我司出示合理的產品質量保證文件，施工 方案、實驗樣板得到客戶一致認可后，簽訂有效合同后，按實際實驗材料 生產此產品，資料索取請聯系我公司，此技術轉讓，任何剽竊行為舉報者有獎!北京海巖興業混凝土外加劑有限公司對本產品每批出廠產品均配有防偽標識，批產品的出廠說明，批產品的性能，批產品的合格證,每批都不同. 每批貨可通過網站，通過客戶的合格證中的“產品批號”查詢真假，并下 載相關施工技術及說明書。查詢登陸“百度”或其他搜索引擎輸入“海巖興業”進入官網即可，本文 由北京海巖興業混凝土外加劑有限公司獨家詮釋，版權所有：北京海巖興 業混凝土外加劑有限公司，網址： www.chi nali ngju 。1

8、 、 UsesInorganic Alu minum Salt Waterproofr Age nt is a soluti on madeby compounding various inorganic salts with inorganic aluminum salt as the mai n comp onent. Whe n it is mixed in to ceme nt mortar, it can form an un permeable, leakproof and moisture resista nt mortar which can be applied on the

9、 surface of buildi ng con structi ons to give a right perma nent waterproof layer.2、Scope of useThe Age nt can be used on surfaces of roof top, and in toilet,un dergr ound baseme nt, water pool, water tower. Warehouse, bridge, tunn el. Sewerage. Dam and air defe nee con structi ons etc. for the purp

10、ose to keep them from damage caused leaki ng water permeati on and moisture effect.3、Mechanism of waterproof action.During setting of the mortar, numerous capillarychannels andorifices may be formed in its n etwork due to evaporati on of water prese nt in the mortar. Whe n “ In orga nic ALUMINUM Sal

11、t Waterpr oof Age nt ” is mixed into the ceme nt mortar, it reacts with the hydrated comp onent of the mortar to form in soluble colloidal alumi num hydroxide and iron hydroxide and .at the same time, react with the hydrated calcium aluminate in the cement to form crystalline calcium aluminum sulfat

12、e complex with expandable properties. These colloidal and orifices and in crease the compact ness of the crystal lattice of the waterproof layer of the concrete to attain its un permeable leak proof property.4、Technical indexes(1 ) Appearanee: Clear brownish yellow liquid with small amount of suspe

13、nded matter.(2 ) Properties of mortar with 15% by weight of“InorganicAlumi num Salt Waterproof Age nt”.(3 ) Weathering test:Sample plates were exposed un der Xenon lamp irradiatio n for300 hours, no cracking, loosing or peeling were observed. The samples rema ined in tact without any sig n of agi ng

14、.5、Pacing, storage and shelf life“ Inorganic Alumi num Salt Waterproof Age nt” is packed in sealed plastic drums of 25 士 1 kg each, n et. It is to be stored in a dry, well ven tilated warehouse away from heat and flame to avoid aging and deformati on of the container.Shelf life of the product is 5 y

15、ears. It can kept for that period with no apparent color change of shrinkage.6、Requirement of concrete materialCement: Use Portland cement. Silica cement or slag cement notlower than 32.5MPa. Different kinds of cement or cement with differe nt stre ngth should not be used together.Sa nd: Use medium

16、size sand as required by conven ti onal mortar.Water: Use clea n tap water7、Working procedure:Treatment of the basementClear away all the dust, lose fragme nts and greasy particles from the baseme nt. Roughe n its smooth surface with chisel to give a roughe ned area not less tha n 75%.Wet the baseme

17、 nt with water.Application of the comling layer.Brush evenly a thin layer of waterproof plain mortar, preferably to a thickness of 2 mm . To improve the adhesive strength between the first layer and the later waterproof sand mortar layer. Compositi on of the waterproof plain mortar: ceme nt: water:“

18、 Ino rga nic Alumi num Salt Waterproof Age nt” (1:2.20:0.10)Application of the first waterproof sand mortar layer.(the leveli ng layer)It is necessary to apply the first waterproof sand mortar layer to the above combining layer before it dnies up. Composition of the waterproof sand mortar: cement: medium size sand: water:“ In orga nic